Post Your Successful Diesel Mods At Dieseldatabase

Have you completed a successful mod on your diesel truck? and did you take pictures and discovered tips that might help others? Your post is welcome here. All you have to do is register on this site. Then contact us via the the contact form on the ABOUT page (see menu), letting us know you […]

Clutch Replacement

TOOLS: Tranny jack 2 or 3 ratchet straps porta power (this will make removing the cross member MUCH eaiser) A bottle jack and a piece of 4×4 will work in a pinch. Drill a hole in the end of the 4×4 to allow the bottle jack shaft to go in the 4×4 a couple of […]

Dodge Cummins Cooling Capacity

5.9 L CTD 22.7 L or 24 Quarts Includes 1 quart for reservoir

Dodge Diesel Injector Comparisons

By popular demand our customers have asked us to show a comparison between the Bosch 275hp RV injector and the Diesel Dynamics True Torque II injector series. This graph shows typical gains with the 275hp RV injectors and DD stages 1,2, and 3. This is a graph of a 99 Cummins Ram with Std Transmission. […]

P7100 Plunger Lift Timing

Bosch P7100 Lift Specs (mm) P7100 Pumps Only Tolerance for Plunger Lift Timing is +/- 0.1mm ( Use CPL number from engine data plate ) Engine Model B5.9160hpExcept CPL 1968 B5.9160hpCPL 1968 Only B5.9180hp B5.9215hp B5.9California CPL Numbers 1549, 15501551, 15521553, 18151816, 19591839 1968 2022, 2174 2023, 2175 1863 Static InjectionTimingdegrees BTDC Lift in mm […]

Pyro Tap Help

Install Help. Note: Tap Size May Vary [thanks to DIS dieselpage.com used with permission]

Stewart Warner B753 Pillar Pod Install Sheet

Click the link below for the pdf version of Stewart Warner B753 Pillar Pod Install Sheet Stewart Warner B753 Pillar Pod Install Sheet [thanks to Stewart Warner sw-performance.com used with permission]

24V CTD Valve Lash Limits

Spec Intake Exhaust Minimum 0.152 mm (0.006 inch) 0.381 mm (0.015 inch) Standard 0.254 mm (0.010 inch) 0.508 mm (0.020 inch) Maximum 0.381 mm (0.015 inch) 0.762 mm (0.030 inch) Adjustments should only be performed when the engine coolant temperature is less than 60°C (140°F).

Dodge Towing Specifications

When Equipped with Cummins Turbo Diesel Dodge RAM 2500 RAM 2500 Reg Cab 4×2 Long Bed Quad Cab 4×2 Short Bed Quad Cab 4×2 Long Bed Trans/Axle GCWR Payload Curb Wt Tow Wt Payload Curb Wt Tow Wt Payload Curb Wt Tow Wt A4/3.55 16,000 3,120 5,679 10,150 2,820 5,981 9,850 2,700 6,096 9,750 A4/4.10 […]

Efficient Engine Montoring

PYRO: Temperatures will vary whenever the throttle is moved or the terrain changes. The peak number is the most important while towing, the ISB can be safely run up to 1450 for short bursts and 1350 all day long. This number is strongly affected by modifications weather it be Air flow or Fuel delivery. If […]

The Dodge Diesel Mystery Switch

These instructions for the mystery switch are for the 47RH not the 47RE. The later transmission control has a relay that has to be removed and the load pins jumped. The ’96 and later also have more than one orange with black tracer wires on the PCM. There are 2 (two) options you have between […]

Service Record Spreadsheet

Click the link below for the Excel version of Service Record Spreadsheet Service Record Spreadsheet [thanks to WBUSA used with permission]

Installing Upfitter Switches in 2005 and Newer Ford Super-Dutys

If you want to add a few aftermarket options to your new Ford Super Duty, Ford Motor Company makes things easy for you. One of the options you can select from the factory is the “UPFITTER SWITCH” option. This is a bank of four switches, with fuses and associated relays, that provide two 30 amp […]

Anti-Freeze Replacement

From Steve St.Laurent : Here’s how I did mine and I got approximately 5.5 gallons into the system, first I opened the petcock on the radiator (turn it, then pull on it a little, turn, pull, turn, pull – until it starts draining), that will drain the fluid out of the overflow bottle, once the […]

The Infamous Cummins 53 Block

Special Thanks to Stamey’s Website for this FAQ about the 53 Block What is the “53” block? The “53” comes from a casting number on the side of the block and is used to identify the problem blocks. Supposedly it affects about 100,000 blocks, but not only in Dodge Rams. Here is information regarding the […]

Ford 6.0L Intercooler Swap for the 7.3L Powerstroke

The swap is relatively inexpensive and not to time consuming. Used 6.0 intercoolers can be had on eBay for around $100-$125. The 6.0 IC is about 30% larger than the 7.3. The original 7.3 PSD intercooler measures 30x18x2 and the 6.0 PSD is 30x21x2.25. One thing you should be aware of before you stat taking […]